CONDITIONS OF BASE: Cured at least for 14 days ( masonry, plaster and against floor) and 28days ( concrete) , clean, dry, flat and sturdy enough . Powder residue , oil or leftover paint , to make cleaning so as not to impair the adhesion of the mortar . If they have imperfections on the surface , they shall be repaired with a minimum of 48 hours before applying the cladding . The former base not replacing loose or hollow sound pieces .
TOOLS AND ACCESSORIES : plastic trough , trowel , steel trowel 6 x 6mm ( smaller than 30x30 pieces) and 8 x 8mm (larger than 30x30 pieces ) with less than 1mm wear on the teeth , a container for action , hammer , rubber spacers plastics for the joints and personal protective equipment such as gloves , boots , goggles .
PREPARATION: Add water in the ratio from 2.85 to 3.15 liters of water for every 15 kg of Superflex floor on fast surface . Knead vigorously until obtaining a homogeneous , consistent and doughy paste. Resting for 5 minutes ( aging time ) before application. Mix again and use no water up to 1 hour 30 minutes after preparation .
APPLICATION: Use the trowel extending with the flat side on the supermassa approximately 4 mm above the base layer , then forming grooves on the toothed side. Lay the pieces not exceeding time of 15 minutes per step . Pressing parts by hand or rubber mallet , completely crushing the strands of supermassa and allowing a perfect grip will play. In size pieces using more than 30x30 cm , or high traffic floors and external areas also apply mortar on the back of the piece. After 1 hour undertake initial cleaning using a clean, damp sponge to remove the existing grout in the joint settlement . After laying away some parts and see if your back is 100 % of your completed by supermassa floor on fast surface area . Release for the personnel work and grouting traffic after 3 to 4 hours. Release to all traffic after 12 hours. 03 days after the settlement soak the coat with water and proceed to final cleaning of parts using Superclean special parts and a clean, damp sponge.
CONSUMPTION: From 4 to 5 kg/m2 lower than 30x30cm pieces . From 7 to 9 kg/m2 larger than 30x30 cm ( double layer ) parts .
SAFETY: Keep out of reach of children and pets. In case of eye contact or accidental ingestion, look for medical advice immediately, taking this packing.
STORAGE: Maximum period of 180 days (with the same criteria recommended for Portland Cement ) .
Bag 20 Kg
© 2013 by SuperMassa. All rights reserved.
Now the chat!
Learn about our companies
For technical support and financial affairs, open a ticket at our Customer Service by clicking here.
For sales questions, contact requests or suggestions, please complete the form below.